Well I have my own opinion on this as my 2000 Trooper is sitting waiting for a new, used motor. Since I cannot drive anywhere I have had lots of time to do research. Here is just a sample of what I have found -
Jeff of Grand Prairie TX (9/14/04):
I own a 1999 Isuzu Trooper with around 67,000 miles on the odometer. I and my family enjoyed the vehicle until about 6 months ago when, on a 250-mile run from San Antonio to my home, I experienced a loud whining and everything lit up like a Christmas tree and the truck went dead. After a long wait and an even longer tow, I had the vehicle checked out and was told that the engine was locked up tight as a drum and that there was just under 1 quart of oil in the pan.
During my ownership of the truck, I had noticed that the dipstick would occasionally and unexpectedly read low - and it never visibly burned any oil. I have owned many classic and high performance vehicles in the past and am a stickler for maintenance. I had changed the oil in the truck around 3000 miles earlier and thought, as any owners manual will tell you, I was keeping up. My immediate thought was that the previous oil change had been done incorrectly - but my own diligence in checking the oil prior to my trip and adding a needed quart steered me away from that as a solution.
Now, after an attempt to locate a replacement engine for the truck online, I find that I'm not alone by any means. Being out of warranty (just) leaves me with the belief that I will just have to eat the cost of getting the vehicle back on the road, but I feel that, given the number of similar stories out there, Isuzu should pony up and assist those who can prove their stories.
My truck is currently being re-diagnosed and repaired after a $285 tow. Initial estimates have indicated that I will likely be out around $3000 for the engine plus several an additional $1000-$2000 in labor.
Robert of Stoughton WI (12/30/03):
We purchased a 1999 Trooper, 3.5 ltr. new in November, 1999. We had the oil changed on a regular basis per recommendations. At the last oil change (October, 2003), Valovine indicated that there was no oil in the motor. We just thought that they had not filled it up properly the last time the oil was changed. At that time, there was less than 60,000 miles on the vehicle. We drove from Wisconsin to Ohio for Christmas which is approximately 580 miles one way. On the way back, the oil light came on in Chicago.
We stopped and put in 2 bottles of 10W30. The oil did not register on the stick. We continued home. We checked the oil when we arrived home and it was not registering again on the stick. We added oil again. The mileage on the vehicle is now 62,000 miles. We contacted Zimbrick's Service Manager and they basically said that the warranty is out and we will need to replace the engine.
Isuzu has known about this problem which occurs in the 1998, 1999 and 2000 3.5 liter vehicles. They corrected the problem with the later 2000 vehicles. It is occuring after the warranty expires in most cases. They did not notify us to indicate there might be a problem with oil consumption. If they had, we would have taken it in after the oil change prior to the warranty expiring. I think Isuzu should back their product. Our vehicle is only 2,000 over the warranty and it was an existing problem that we were not aware of.
We may have to replace the engine, which would cost more than what the vehicle is worth. We still owe one year of a five-year loan, approximately $4,000.00. It would be stupid to replace the engine and incur $6,000-7,000 in expense for a vehicle that isn't worth that.
Toynie of Palm Coast FL (11/25/03):
In October of 1998 we purchased a 1998 Isuzu Trooper with a 6-year or 100,000 mi. extended warranty. It was not until the fall of this year when my husband was returning from the beach with our three-year-old daughter and the motor blew up that we found out it was underwritten by Smart Choice and that the company was now bankrupt. Then we found out that we would have to pay in the neighborhood of $3,000 to $6,000 for a new motor.
etc. My engine seized on me on the way back from a trip. There are no oil leaks or anything that would indicate a problem. I now need a new long block on a perfectly good truck. This is major money. Thanks for listening.
Joseph of Shreveport (1/28/03):
I own a 99 Isuzu Trooper. I bought it new. In November 2002, as I was headed out of town my oil light came on. I immediately stopped the vehicle and popped the hood to see what was going on with my oil. I checked the oil stick and found that it showed the oil level as full. I got back in the vehicle and drove about a mile.
Suddenly, I heard a loud rumbling sound coming from under the hood. The dashboard lit up, and the engine went dead. I pulled off to the side of the road, looked under the hood and could smell something like burning rubber. When tried to restart it nothing happened. Later, I had it towed into the dealership, which said it looked as if the engine blew up. He stated that it could cost as much as $12,000 to have the engine rebuilt. He knew of a used one that he could get for about $5,000 and that it would cost a total of about $7,100 including installation.
Of course, I had no way of coming up with that kind of money. I later found a number from the internet to the Isuzu manufacturer. It took me forever to speak to someone and when I did they offered no help at all. They were only concerned that the warranty had gone out and were under no further obligation. This vehicle has a 60,000-mile warranty; I had about 76,000 miles on it when the trouble happened. To say the least, I am very disappointed with Isuzu. This is my third Trooper I've purchased from this dealership. I thought that would have counted for something.
Amy of Fort Worth, TX writes (10/26/02):
Purchased a 1995 Isuzu Trooper in 1997. The engine went out 3 months ago. No engine to replace it can be found and in our looking for an engine we discovered that this model Trooper had a known wrist pin problem in the engine and that is why we can't find one today to replace it. Even if we did find one the same problem would happen so why would we buy an engine new or rebuilt just to have it do the same thing? One rebuilt engine we found was $4500 plus shipping plus installation from a mechanic. I think that is absurd when in any other NEW car you can get a new engine for that much if not less. Isuzu won't help us and claims they "know nothing" of this problem. I say BS.
Pamela of East Bridgewater, MA (8/19/02):
I purchased at the end of my lease a 1997 Isuzu Trooper. I felt I was the only owner and it only had 36,000 miles on the car. I haven't had any real trouble with the car. I have taken care of the car with oil changes, rotating the tires, tune-ups, etc. Well then my car begins to make this horrible wrapping noise and smoking. I called the dealer and they said they couldn't look at the car for at least a week. I need the car for transportation back and forth to work. I found another reputable mechanic that used to work for the dealer and now owns his own shop.
After doing a diagnostic test on the car he explained that it needed an oil pump. I spent $1100 for this job. After picking up the car it began to make other noises. I asked what this was and he stated that it sounded like the lower portion of the motor. I wanted to make sure that he was right so I made an appointment to have them diagnose the problem and confirmed the problem. I asked if there was anyone from Isuzu that I could speak to about this and they stated that the service manager would need to speak to the Isuzu factory representative. He stated that he would do this on Monday of the following week. I called the service manager to remind him and he placed me on hold for approx. 3.2 minutes and came back with a flat no. Isuzu is not responsible and I am out of warranty so basically thanks for nothing.
I tried to contact the customer service department to get this individuals number so that I could advocate for myself the situation and possibly explain my situation. But again I was told that the service manager would speak on my behalf. I feel that a car motor should last more than 71,000 miles and that I will make sure that I never purchase or my family will never purchase or anyone I can possibly talk out of purchasing an Isuzu vehicle.
I have three children and they are beginning school in a couple of weeks. I had to spend $1100 and then be told the motor is no good. I wasn't looking for a free ride but I am looking for some help. I was never offered at the end of my lease an option to purchase an extended warranty. If I was I would have it to cover me in situations such as this.
Howard of Chicago (6/5/01):
I own a 99 Isuzu Vehicross [same engine as the 99 Trooper] with 35,000 miles. Last month the engine seized, and apparently needs to be replaced. Although the warranty is still in effect, Isuzu refuses to honor it. They say I have to document oil changes every 3000 miles and should've checked the engine oil level every other time I filled the gas tank. My limited search on the web has revealed that numerous Isuzu owners with V6 engines have unexplained engine oil loss. Isuzu knows about this but refuses to do anything to warn consumers except a single line in the owners manual about checking the oil every second gas fill-up. The oil warning light also does not warn of loss of oil. Isuzu wants $6500 cash to replace the engine
. . . and last but certainly not least . . .
From a Better Business Bureau posting
Have you had engine failure problems with your Trooper?
My 1999 Isuzu Trooper is on its fourth engine. After complaining of excessive oil usage in my first (a 1994) Trooper, and being told it was normal, a wrist pin in the engine failed at 110K miles. Isuzu would do nothing, but the dealer moved me into a new '99 Trooper.
I watched the oil consumption very carefully with dealer documentation. At 57K miles they agreed it used too much oil and Isuzu put a new long block in the vehicle. The oil consumption dropped to nearly nothing and the engine seemed fine.
At about 45K miles on the new engine, and while driving on the Interstate at 70 mph in cruise control, the engine came apart with no warning. Pistons and rods went through the side of the block and out the bottom of the oil pan. It turns out that Isuzu only warranties their replacement motors for 12K miles -- not the 60K plus they cover in the original equipment motors ?!?!
Isuzu would do nothing about this and I ended up putting a new motor in at the cost of $7500. The dealer actually had to put in a second long block because the first one came apart when they started it!!!!!!!
This morning, with less than 6K miles on this new engine a metallic noise started in the engine. It is at the dealer's now and I dread the outcome.
Back to my Trooper again. I am still waiting for the used engine of which there are none because they are all used up as replacements!
We all need to face facts. These things are junk! The company is will not support its customers. We all need to find a new marque to support - one that works, with a manufacturer that supports us !!!!!!!